1.Key Lab of Industrial Computer Control Engineering of Hebei Province, Yanshan University, Qinhuangdao, Hebei 066004, China;
2.National Engineering Research Center for Equipment and Technology of Cold Strip Rolling, Qinhuangdao, Hebei 066004, Chin
Abstract：Taking into account the problem that the heat rate of steam turbine is difficult to accurately calculate, a novel heat rate multi-model soft measurement methodology based on kernel fuzzy c-means and shuffled frog-leaping algorithm optimized least squares support vector machine(LS-SVM is proposed), which is employed to calculate the heat rate under different working conditions. This method applies kernel fuzzy c-means algorithm clustering heat rate data. Taking the mean error of 5-fold cross-validation as fitness value of parameters selection for LS-SVM, LS-SVM based on SFLA is trained and established local model for each cluster, and then the model output is obtained by the switch way, so as to realize the heat rate multi-model method. Compared with the single LS-SVM model and BP network heat rate prediction model, the multi-model has a higher prediction accuracy and better generalization ability.
［1］王雷,张欣刚,王洪跃,等.基于支持向量回归算法的汽轮机热耗率模型［J］.动力工程,2007,27(1):19-23.
［2］陈鸿伟,刘焕志,李晓伟,等.双循环流化床颗粒循环流率试验与BP神经网络预测［J］.中国电机工程学报,2010,30(32):25-29.
［3］李岩,王东风,焦嵩鸣,等.采用微分进化算法和径向基函数神经网络的热工过程模型辨识［J］.中国电机工程学报,2010,30(8):110-116.
［4］Vapnik V. The nature of statistical learning theory［M］.New York:Springer,1995.
［5］叶林,刘鹏.基于经验模态分解和支持向量机的短期风电功率组合预测模型［J］.中国电机工程学报,2011,31(31):102-108.
［6］Liu G H, Zhou D W, Xu H X, et al. Model optimization of SVM for a fermentation soft sensor［J］.Expert Systems with Applications,2010,37(4):2708-2713.
［7］Wang P,Tian J W,Gao C Q.Infrared small target detection using directional highpass filters based on LS-SVM［J］.Electronics Letters,2009,45(3):156-158.
［8］Eusuff M,Lansey K,Pasha F. Shuffled frog-leaping algorithm:a memetic meta-heuristic for discrete optimization［J］.Engineering Optimization,2006,38(2):129-54.
［9］王洋课.基于聚类的多模型软测量技术的研究［D］.南京:东南大学,2010.
［10］Niu P F, Zhang W P.Model of turbine optimal initial pressure under off-design operation based on SVR and GA［J］. Neurocomputing, 2012, 78(1):64-71.
2015, Vol. 36 
