基于噪声模板与互相关计算的涡街流量计抗强振动方法

doi:10.3969/j.issn.1000-1158.2015.01.09

摘要
图/表
参考文献(13)
相关文章 (15)

全文: PDF (516 KB) HTML (1 KB)
输出: BibTeX | EndNote (RIS)

摘要根据涡街流量计在工作现场受强振动噪声干扰的情况,搭建振动实验平台,进行振动实验。对采集的数据进行功率谱分析和带宽特征分析,建立噪声模板,并量化描述噪声的带宽特性。进行噪声模板与传感器输出信号功率谱的互相关计算,提出利用噪声和涡街信号归一化互相关系数曲线进行噪声判别的抗强振动干扰的方法。对振动实验中采集的传感器数据进行处理,验证了该方法的有效性。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	徐科军
	王沁
	方敏
	邵春莉

关键词 ：计量学, 涡街流量计, 强振动干扰, 噪声模板, 互相关计算, 归一化互相关系数曲线

Abstract：A vibration experimental set-up of the vortex flowmeter is built and the vibration experiments are performed according to practical conditions of vortex flowmeter subjected to the strong vibration noise in industrial fields. The experimental data are analyzed by the power spectrum to obtain the features of frequency bandwidth. The noise templates are built up, and the frequency bandwidth characteristics of noise are described quantitatively. Cross correlation between the noise template and the power spectrum of vortex sensor output signal is calculated. A new kind of method is proposed by using the normalized cross correlation coefficient curves of the noise and vortex signal so as to distinguish the vortex signal from the strong vibration noise. The experimental data collected in the vibration experiments are processed with this algorithm to verify its effectiveness.

Key words： Metrology Vortex flowmeter Strong vibration Noise template Cross correlation calculation Normalized cross correlation coefficient curve

基金资助:国家自然科学基金(61074164)

作者简介: 徐科军（1956-）,男,江苏无锡人,合肥工业大学教授、博士生导师,主要从事传感器技术、自动化仪表和数字信号处理研究。dsplab@hfut.edu.cn.

引用本文:

徐科军,王沁,方敏,邵春莉. 基于噪声模板与互相关计算的涡街流量计抗强振动方法[J]. 计量学报, 2015, 36(1): 37-42.
XU Ke-Jun,WANG Qin,FANG Min,SHAO Chun-li. The Anti-strong Vibration Method Based on Noise Template and Cross Correlation Calculation for Vortex Flowmeter. Acta Metrologica Sinica, 2015, 36(1): 37-42.

链接本文:

http://jlxb.china-csm.org:81/Jwk_jlxb/CN/10.3969/j.issn.1000-1158.2015.01.09 或 http://jlxb.china-csm.org:81/Jwk_jlxb/CN/Y2015/V36/I1/37

［1］Amadi-echendu J E,Zhu H J,Higham E H.Analysis of signal from vortex flowmeters［J］.Flow Measurement and Instrumentation,1993,4(4):225-231.
［2］Ghaoud T,Clark D W.Modelling and tracking a vortex flow-meter signal［J］.Flow Measurement and Instrumentation,2002,13:103-117.
［3］Clark D W,Ghaoud T.A dual phase locked loop for vortex flowmetering［J］.Flow Measurement and Instrumentation,2003,14:1-11.
［4］徐科军,汪安民.基于小波变换的涡街流量计信号处理方法［J］.仪器仪表学报,2001,22(6):636-639.
［5］张涛,吴鹏.基于子波变换的涡街流量传感器信号分析［J］.计量学报,2003,24(3):199-201.
［6］黄咏梅,张宏建,等.新DFT递推算法在涡街流量信号处理中的应用［J］.浙江大学学报(工学版),2003,37(1):51-55.
［7］Xu K J,Huang Y Z,Lü X H.Power-spectrum-analysis-based Signal Processing System for Vortex Flowmeters［J］.IEEE Trans on IM,2006, 55(3):1006-1011.
［8］曾宪俊,徐科军,周杨,等.低功耗、两线制涡街流量计数字信号处理系统［J］.仪表技术与传感器,2009, (1): 76-79.
［9］徐科军,刘三山,刘家祥,等.基于数字频谱与模拟带通滤波组的两线制涡街流量计［J］.计量学报,2011,32(1): 25-30.
［10］徐科军,罗清林,朱永强,等.涡街流量传感器信号的幅值和频率特征［J］.计量学报,2010,31(6):504-508.
［11］Schlatter G L,Barrett W D,Waers J F,et al. Signal processing method and apparatus for flowmeters:WO,1990004230［P］.1990-04-19.
［12］Xu K J, Luo Q L, Wang G. Frequency-feature based anti-strong disturbance signal processing method and system for vortex flowmeter with single sensor［J］. Review of Scientific Instuments,2010,81(7):075104-7.
［13］Xu K J,Luo Q L,Fang M. Anti-strong-disturbance signal processing method of vortex flowmeter with two sensors［J］.Review of Scientific Instruments,2011, 82(9):096105.