Abstract：In order to solve the problem that the weak fault signal of rolling bearing is difficult to be detected, a new method based on a new nonlinear coupled bistable stochastic resonance model is proposed. Under the background of noise, stochastic resonance can enhance the output of weak signal and improve the detection of weak signal. The nonlinear coupled bistable system proposed in this paper is composed of two single bistable system with nonlinear coupling. The influence of different parameters on the phenomenon of stochastic resonance are researched through the analysis of the damping coefficient and the coupling coefficient, with the noise intensity change SNIR (signal to noise improvement ratio) response curve. The results show that the coupled bistable system is more robust than the single bistable system. In the end, the bearing fault of weak signal was enhanced by using this detection model, the proposed nonlinear coupled bistable stochastic resonance can detect weak fault signal noise in complex background.
时培明,孙鹏,袁丹真. 基于非线性耦合双稳态随机共振的轴承微弱故障信号增强检测方法研究[J]. 计量学报, 2018, 39(3): 373-376.
SHI Pei-ming,SUN Peng,YUAN Dan-zhen. Research on the Enhanced Detection Method of Bearing Fault Weak Fault Signal Based on Nonlinear Coupled Bistable Stochastic Resonance. Acta Metrologica Sinica, 2018, 39(3): 373-376.
［1］Xue H, Wang H, Chen P, et al. Automatic diagnosis method for structural fault of rotating machinery based on distinctive frequency components and support vector machines under varied operating conditions［J］. Neurocompution, 2013, 116: 326-335.
［2］Randall R B. Vibration-based Condition Monitoring: Industrial Aerospace and Automotive Applications［J］. Mechanisms & Machine Science, 2010, 3(4):431-477
［3］孟宗,刘东,岳建辉,等.基于DEMD局部时频熵和SVM的风电齿轮箱故障诊断方法研究［J］. 计量学报,2017,38（4）: 449-452.
［4］袁静, 何正嘉, 訾艳阳. 基于提升多小波的机电设备复合故障分离和提取［J］. 机械工程学报, 2010, 46(1):79-85.
［5］雷亚国. 基于改进Hilbert-Huang 变换的机械故障诊断［J］. 机械工程学报, 2011, 47(5):71-77.
［6］McNamara B, Wiesenfield K. Theory of stochastic resonance［J］. Physical Review A, 1989, 39(9):4854-4869.
［7］Dykman M I, Mannella R, Mcclintock P V,et al. Fluctuation-induced transitions between periodic attractions: observation narrow spetral peaks near a kinetic phase trasition［J］. Physical Review Letters, 1990, 65(1):48-51.
［8］Fauve S, Heslot E. Stochastic resonance in a bistable system［J］.Physical Review Letters, 1983, 97(1):5-7.
［9］McNamara B, Wiesenfield K, Roy R. Observation of stochastic resonance in a ring laser［J］. Physical Review Letters, 1988, 60(25):2626-2629.
［10］Gammaitoni L, Marchesoni F,Menichellasaetta E,et al. Multiplicative stochastic resonance［J］. Physical Review Letters, 1989, 62(4):349-352.
［11］Barzykin A V, Seki K. Stochastic resonance drivrn by Gaussian multiplicative noise［J］.Epl, 1997, 40(2):117-121.
［12］Mankin R, Ainsaar A,Haljas A,et al. Trichotomous-noise-induced catastrophic shifts in symbiotic ecosystems［J］.Phys Rev E,2002, 65(5Pt1): 051108.1-051108.9.
［13］Mankin R, Soika E, Sauga A. Multiple noise-enhanced stability versus temperature in asymmertric bistable potential［J］.Dynamics,2008, 16(21):239-250.
［14］Soika E, Mankin R. Response of a fractional oscillator to multiplicative trichotomous noise［J］. Wseas Transactions on Biology & Biomedicine,2010 ,7(1):21-30.
［15］李继猛,张云刚,张金凤,等. 基于自适应随机共振的齿轮微弱冲击故障信号增强提取方法研究［J］. 计量学报,2017,38（5）: 602-606.
［16］Gandhimathi V M, Rajasekar S, Kurths J. Vibrational and stochastic resonances in two coupled overdamped anharmonic oscillators［J］. Phys Lett A,2006, 360(2):279-286.
［17］Makra P, Gingl Z. Signal-to noise ratio gain in non-dynamical and dynamical bistable stochastic resonators［J］. Fluctuation and Noise Letters, 2002, 2(3):145-153.
［18］Heneghan C, Chow C C, Collins J J, et al. Information measures quanifying aperiodic stochastic resonance［J］. Phys Rew E, 1996, 54(3):R2228-R2231.
2018, Vol. 39 
