Abstract：In order to study the influences of the heat transfer modes on the dynamic characteristics of temperature sensors, the relationship between the heat transfer mode and the dynamic characteristics of temperature sensors was derived by the theory of time constant, and the dynamic characteristics of temperature sensors were analyzed under different heat transfer modes. The heat transfer models of the temperature sensors were established with the modes of convection heat transfer and radiation heat transfer, and the thermocouple time constant were tested via the oil bath method and the pulsed laser method. The test results showed that the time constant test values of the thermocouple in convection heat transfer and radiation heat transfer mode are 1.2s and 6.2s respectively. It can be seen that the heat transfer mode directly affects the dynamic characteristics of the temperature sensor, and finally the rationality of the heat transfer model can be verified by comparing the test values and the theoretical calculations values.
贾超,蔡杰,熊朝晖. 不同传热方式下温度传感器动态特性研究[J]. 计量学报, 2020, 41(5): 563-566.
JIA Chao,CAI Jie,XIONG Zhao-hui. Study on Dynamic Characteristics of Temperature Sensors under Different Heat Transfer Modes. Acta Metrologica Sinica, 2020, 41(5): 563-566.
［1］徐科军. 传感器动态特性的实用研究方法［M］. 合肥: 中国科学技术大学出版社, 1999.
［2］张根甫, 郝晓剑, 桑涛, 等. 热电偶温度传感器动态响应特性研究［J］. 中国测试, 2015, 41(10): 68-72.
Zhang G F, Hao X J, Sang T, et al. Study on the Dynamic Response of Thermocouple Temperature Sensor［J］. China Measurement & Test, 2015, 41(10): 68-72.
［3］Kocharyan S A, Solopchenko G N. Unifying Dynamic Temperature Measurements and Methods of Determining Complete Dynamic Characteristics for primary Standard Water-flow Thermometers［J］. Measurment Techniques, 2002, 8(45): 861-869.
［4］吴方, 杨新圆, 王莉. 表面温度传感器时间常数测量方法研究［J］. 计测技术, 2014, 34(4): 60-62.
Wu F, Yang X Y, Wang L. Study on Measuring Time Constants of Surface Temperature Sensors［J］. Metrology & Measurement Technology, 2014, 34(4): 60-62.
［5］方立德, 张计科, 王农, 等. K型热电偶动态响应特性研究［J］. 电子测量技术, 2010, 33(11): 18-20.
Fang L D, Zhang J K, Wang N, et al. Study on Dynamic Response on Characteristics of K-type Thermocouple ［J］. Electronic Measurement Technology, 2010, 33(11): 18-20.
［6］Ireland P T, Jones T V. The response time of surface thermometer employing encapsulated thermochromic liquid crystal［J］. J Phy E: Sci Instrum, 1987, 20(10): 1195-1199.
［7］赵时安, 廖理, 陈勇. 1700℃校准风洞［J］. 航空计测技术, 2000, 20(4): 58-61.
Zhao S A, Liao L, Chen Y. 1700℃ Hot Wind Tunnel for Thermal Calibration［J］. Aviation Metrology & Measurement Technology, 2000, 20(4): 58-61.
［8］王毅, 赵俭. 动态温度测量与校准技术［J］. 计测技术, 2015, 35(1): 9-13.
Wang Y, Zhao J. Dynamic Temperature Measurement and Calibration Technology［J］. Metrology & Measurement Technology, 2015, 35(1): 9-13.
［9］Castellini P, Rossi G L. Dynamic characterization of temperature sensors by laser excitation［J］. Review of Scientific Instruments, 1996, 67(7): 2595-2601.
［10］郝晓剑. 瞬态表面高温测量与动态校准技术研究［D］. 太原: 中北大学, 2005.
［11］梁列国, 周汉昌, 潘德恒. 瞬态表面温度传感器的校准技术研究［J］. 兵工学报, 2001, 22(2): 263-265.
Liang L G, Zhou H C, Pan D H. A Study on the Method of Calibration for Transient Surface Temperature Detectors［J］. Acta Armamentarii, 2001, 22(2): 263-265.
［12］殳伟群. 动态测量不确定问题初探［J］. 计量学报, 2003, 24(3): 245-249.
Shu W Q. A Study of the Dynamic Measurement Uncertainty［J］. Acta Metrologica Sinica, 2003, 24(3): 245-249.
［13］国家技术监督局. JJF 1049-1995 温度传感器动态响应校准技术规范［S］. 1995.
［14］郑玮, 杨振华, 向明东. 在液槽中测试热电偶不均匀性方法探索［J］. 计量学报, 2013, 34(4): 356-359.
Zheng W, Yang Z H, Xiang M D. Study of Inhomogenetity Test on Thermocouple in Liquid Bath［J］. Acta Metrologica Sinica, 2013, 34(4): 356-359.
［15］葛新石, 叶宏. 传热与传质基本原理［M］. 北京: 化学工业出版社, 2007.
［16］王晓娜, 于方舟, 杨遂军. 基于集总热容法的薄膜热电偶动态特性研究［J］. 传感技术学报, 2014, 27(12): 1627-1631.
Wang X N, Yu F Z, Yang S J. Study on TFTC Dynamic Character Based on Lumped Capacitance Method ［J］. Chinese Journal of Sensors and Actuators, 2014, 27(12): 1627-1631.
2020, Vol. 41 
