面向批料流测量的科氏质量流量计正交解调方法实现

doi:10.3969/j.issn.1000-1158.2020.07.07

摘要
图/表
参考文献(16)
相关文章 (15)

全文: PDF (1001 KB) HTML (1 KB)
输出: BibTeX | EndNote (RIS)

摘要为了提高科氏质量流量计在批料流工况下的测量精度,根据正交解调算法具有快速响应的特点,选取该算法作为批料流下的信号处理方法,并解决实现过程中的技术难点。利用正弦信号周期性的特点,实现解调信号单周期有限点数据循环调用;采用FIR陷波器和IIR低通滤波器级联完成对解调后信号的滤波,在保证滤波效果的同时降低了算法运算量;为了去除计算结果中的奇异点同时减小稳态波动,在相位差后期处理中加入两级平均;优化了算法实现过程中的资源分配。在此基础上,研制了科氏质量流量变送器,并进行了单相流和批料流标定实验,其测量误差小于0.1%,重复性小于0.05%。实验结果表明,正交解调算法在批料流下具有较好的测量精度,同时所研制的变送器具有较好的性能。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	张伦
	徐科军
	徐浩然
	乐静
	刘文
	刘陈慈
	黄雅

关键词 ：计量学, 批料流, 科氏质量流量计, 正交解调

Abstract：In order to improve the measurement accuracy of the Coriolis mass flowmeter under batch flow conditions,the quadrature demodulation algorithm is selected as the signal processing method according to the characteristics of rapid response,it solves the difficulties in the implementation process. the demodulation signal with single period finite point data is realized by using the periodic characteristics of the sinusoidal signal;besides the demodulated signals are filtered by cascading the FIR notch filter and the IIR low-pass filter while guarantee accuracy and reduce algorithmic computation;a secondary average is added in the post-processing in order to reduce the steady-state fluctuations and remove the singular points in the calculation results,in addition,the resource configuration during algorithm implementation is optimized. On this basis,the Coriolis mass flow transmitter was developed,and the single-phase flow and batch flow calibration experiments were carried out. The measurement error was less than 0.1% and the repeatability was less than 0.05%. The experimental results show that the quadrature demodulation algorithm has better measurement accuracy under the batch flow,and the developed transmitter has better performance.

Key words： metrology batch flow Coriolis mass flowmeter quadrature demodulation

收稿日期: 2018-10-24 发布日期: 2020-06-29

PACS:

TB937

通讯作者: 徐科军(1956-), 男, 江苏无锡人, 合肥工业大学教授、博士生导师,主要从事传感器技术、自动化仪表和数字信号处理方面的研究。Email: dsplab@hfut.edu.cn E-mail: dsplab@hfut.edu.cn

作者简介: 张伦(1993-), 男, 山东济宁人, 合肥工业大学在读硕士研究生, 研究方向为信号处理技术。Email: 1195941491@qq.com

引用本文:

张伦,徐科军,徐浩然,乐静,刘文,刘陈慈,黄雅. 面向批料流测量的科氏质量流量计正交解调方法实现[J]. 计量学报, 2020, 41(7): 808-815.
HANG Lun,XU Ke-jun,XU Hao-ran,YUE Jing,LIU Wen,LIU Chen-ci,HUANG Ya. Realization of Quadrature Demodulation Method for Coriolis Mass Flowmeter under Batch Flow Measurement. Acta Metrologica Sinica, 2020, 41(7): 808-815.

链接本文:

http://jlxb.china-csm.org:81/Jwk_jlxb/CN/10.3969/j.issn.1000-1158.2020.07.07 或 http://jlxb.china-csm.org:81/Jwk_jlxb/CN/Y2020/V41/I7/808

［1］Martin A, Drahm W, Rieder A. Coriolis mass flowmeters: Overview of the current state of the art and latest research［J］. Flow Measurement and Instrumentation, 2006, 17(6):317-323.
［2］Wang T, Baker R. Coriolis flowmeters: a review of developments over the past 20 years,and an assessment of the state of the art and likely future directions［J］. Flow Measurement and Instrumentation, 2014, 40: 99-123.
［3］Hou Q L, Xu K J, Fang M, et al. A DSP-based signal processing method and system for CMF ［J］. Measurement, 2013, 46(7):2184-2192.
［4］Henry M P, Clarke D W, Archer N, et al. A self-validating digital Coriolis mass-flow meter: an overview ［J］. Control Engineering Practice, 2000, 8(5):487-506.
［5］Wang T, Hussain Y. Investigation of the batch measurement errors for single-straight tube Coriolis mass flowmeters［J］. Flow Measurement and Instrumentation, 2006, 17(6):383-390.
［6］Tombs M,Henry M,Zhou F B,et al. High precision Coriolis mass flow measurement applied to small volume proving［J］. Flow Measurement and Instrumentation, 2006, 17(6):371-382.
［7］郑德智, 樊尚春, 邢维巍. 科氏质量流量计相位差检测新方法［J］. 仪器仪表学报, 2005, 26(5):441-444.
Zheng D Z, Fan S C, Xing W W. The novel method of phase difference detection in Coriolis mass flowmeter ［J］. Chinese Journal of Scientific Instrument, 2005,26(5): 441-444.
［8］刘翠, 侯其立, 熊文军. 面向微弯型科氏质量流量计的高精度过零检测算法实现［J］. 电子测量与仪器学报, 2014, 28(6):675-682.
Liu C, Hou Q L, Xiong W J. Implementation of high-precision zero-crossing detection algorithm for micro-bend type Coriolis mass flowmeter［J］. Journal of Electrnic Measurement and Instrumentation, 2014, 28(61):675-682.
［9］倪伟, 徐科军. 基于时变信号模型和归一化格型陷波器的科氏流量计信号处理方法［J］. 计量学报, 2007, 28(3):243-247.
Ni W,Xu K J. Signal Processing Method of Coriolis Flowmeter Based on Time-varying Signal Model and Normalized Lattice Notch Filter［J］. Acta Metrologica Sinica, 2007, 28(3):243-247.
［10］徐科军, 徐文福. 基于AFF和SGA的科氏质量流量计信号处理方法［J］. 计量学报, 2007, 28(1):48-51.
Xu K J, Xu W F. Signal Processing Method of Coriolis Mass Flowmeter Based on AFF and SGA［J］. Acta Metrologica Sinica, 2007, 28(1): 48-51.
［11］徐科军, 徐文福. 基于正交解调的科里奥利质量流量计信号处理方法研究［J］. 仪器仪表学报, 2005, 26(1):23-27.
Xu K J, Xu W F. Research on Signal Processing Method Based on Quadrature Demodulation for Coriolis mass Flowmeter［J］. Chinese Journal of Scientific Instrument, 2005, 26(1):23-27.
［12］张建国, 徐科军, 董帅, 等. 基于希尔伯特变换的科氏质量流量计信号处理方法研究与实现［J］. 计量学报, 2017, 38(3):309-314.
Zhang J G, Xu K J, Dong S,et al. Study and Implementation of Signal Processing Method for Coriolis Mass Flowmeter Based on Hilbert Transform［J］. Acta Metrologica Sinica, 2017, 38(3):309-314.
［13］张海涛,涂亚庆. 计及负频率影响的科里奥利质量流量计信号处理方法［J］. 仪器仪表学报, 2007, 28(3):539-541.
Zhang H T,Tu Y Q. New signal processing method with negative frequency contribution for Coriolis mass flowmeter［J］. Chinese Journal of Scientific Instrument, 2007, 28(3):539-541.
［14］Dietmar Stadler,Measurement and Operation Circuit of a Coriolis-type mass flow meter:US6073495［P］. 1998-03-16.
［15］Manus P. Henry,Digital Measurement:US20020038186［P］. 2002-05-28.
［16］刘翠, 徐科军, 侯其立, 等. 适用于频繁启停流量测量的科氏质量流量计信号处理方法［J］. 计量学报, 2014, 35(3):242-247.
Liu C, Xu K J, Hou Q L, et al. Signal processing method for Coriolis mass flowmeters for frequent start-stop flow measurement［J］. Acta Metrologica Sinica, 2014, 35(3):242-247.