基于驱动特性图法的科氏流量计模拟驱动设计

doi:10.3969/j.issn.1000-1158.2020.08.10

摘要
图/表
参考文献(16)
相关文章 (15)

全文: PDF (1153 KB) HTML (1 KB)
输出: BibTeX | EndNote (RIS)

摘要传感器的稳幅振动是科氏质量流量计工作的前提。当被测液体流量中含有气体时,传感器的振动阻尼增大,需要的驱动能量增加。而已有模拟驱动无法及时提供所需能量,致使传感器停振。为此,绘制已有模拟驱动的驱动特性曲线,分析其存在的问题,进而推导新型模拟驱动的驱动特性曲线,设计出能同时工作于单相流和气液两相流下的新型模拟驱动电路。在持续气液两相流和单相流-气液两相流切换下,进行了已有模拟驱动和新型模拟驱动的对比实验。结果表明:新型模拟驱动的驱动稳定性和快速性均优于已有模拟驱动。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	徐浩然
	徐科军
	张伦
	刘文
	乐静
	黄雅
	刘陈慈

关键词 ：计量学, 科氏质量流量计, 驱动特性图, 模拟驱动, 气液两相流, 传感器停振

Abstract：The steady vibration of the sensor is a prerequisite for the operation of the Coriolis mass flowmeter. When the measured liquid flow contains gas, the vibration damping of the sensor increases, and the required driving energy should be increased. However, existing analog drivers are unable to provide the required energy in time, causing the sensor to stop vibrating. To this end, the drive characteristic curve of the existing analog drive was drawn, and the existing problems were analyzed. Then the drive characteristic curve of the new analog drive was derived, and a new analog drive circuit capable of working simultaneously under single-phase flow and gas-liquid two-phase flow was designed. Under the continuous gas-liquid two-phase flow and single-phase flow-gas-liquid two-phase flow switching, the existing analog drive and the new analog drive comparison experiment were carried out. The results showed that the driving stability and fastness of the new analog drive are better than the existing analog drive.

Key words： metrology Coriolis mass flowmeter drive characteristic diagram analog driver gas-liquid two-phase flow sensor stop vibration

收稿日期: 2019-01-18 发布日期: 2020-08-13

PACS:

TB937

通讯作者: 徐科军(1956-),男,江苏无锡人,合肥工业大学教授,博士生导师,主要从事传感器技术、自动化仪表和数字信号处理方面的研究。Email: dsplab@hfut.edu.cn E-mail: dsplab@hfut.edu.cn

作者简介: 徐浩然(1995-),男,安徽六安人,合肥工业大学研究生,研究方向为自动化仪表。Email: 978028253@qq.com

引用本文:

徐浩然,徐科军,张伦,刘文,乐静,黄雅,刘陈慈. 基于驱动特性图法的科氏流量计模拟驱动设计[J]. 计量学报, 2020, 41(8): 953-959.
XU Hao-ran,XU Ke-jun,ZHANG Lun,LIU Wen,YUE Jing,HUANG Ya,LIU Chen-ci. Analog Drive Design of Coriolis Flowmeter Based on Driving Characteristic Diagram Method. Acta Metrologica Sinica, 2020, 41(8): 953-959.

链接本文:

http://jlxb.china-csm.org:81/Jwk_jlxb/CN/10.3969/j.issn.1000-1158.2020.08.10 或 http://jlxb.china-csm.org:81/Jwk_jlxb/CN/Y2020/V41/I8/953

［1］Anklin M, Drahm W, Rieder A. Coriolis mass flowmeters: Overview of the current state of the art and latest research ［J］. Flow Measurement & Instrumentation, 2006, 17(6): 317-323.
［2］徐科军, 徐文福. 科式质量流量计模拟驱动方法研究［J］. 计量学报, 2005, 26(2): 149-152.
Xu K J, XU W F. Research on analog driving methods of Coriolis mass flow meter［J］. Acta Metrologica Sinica, 2005, 26(2): 149-152.
［3］李苗, 徐科军, 朱永强, 等. 科氏质量流量计的3种驱动方法研究［J］. 计量学报, 2011, 32(1): 36-39.
Li M, Xu K J, Zhu Y Q, et al. Studies on three driving methods of Coriolis mass flowmeter ［J］. Acta Metrologica Sinica, 2011, 32(1): 36-39.
［4］熊文军, 徐科军, 方敏, 等. 科氏流量计一次仪表与变送器匹配方法研究［J］. 电子测量与仪器表学报, 2012, 26(6): 521-528.
Xiong W J, Xu K J, Fang M, et al. Study on matching method of primary meter and transmitter in Coriolis mass flowmeter ［J］. Journal of Electronic Measurement & Instrument, 2012, 26(6): 521-528.
［5］刘铮. 科氏质量流量计驱动系统中关键技术研究［D］. 合肥:合肥工业大学, 2016.
［6］方正余, 徐科军, 张建国, 等. 科氏质量流量计差分驱动方式研究与实验［J］. 电子测量与仪器学报, 2017, 31(12): 2030-2035.
Fang Z Y, Xu K J, Zhang J G, et al. Research and experiment on differential drive mode of Coriolis mass flowmeter ［J］. Journal of Electronic Measurement & Instrument, 2017, 31(12): 2030-2035.
［7］朱永强. 数字式科氏质量流量变送器硬件研制［D］. 合肥:合肥工业大学, 2010.
［8］马亚朋,石础,罗宇, 等. 科氏流量计气-液两相流的数值模拟［J］. 计量学报, 2018, 39(5): 663-667.
Ma Y P, Shi C, Luo Y, et al. Numerical Simulation of Gas-liquid Two-phase Flow in Coriolis Flowmeter［J］. Acta Metrologica Sinica, 2018, 39(5): 663-667.
［9］刘翠, 徐科军, 侯其立,等. 适用于频繁启停流量测量的科氏质量流量计信号处理方法. 计量学报, 2014, 35(3): 242-247.
Liu C, Xu K J, Hou Q L, et al. Signal processing method for Coriolis mass flowmeters for frequent start-stop flow measurement［J］. Acta Metrologica Sinica, 2014, 35(3): 242-247.
［10］Clarke D W. Non-linear control of the oscillation amplitude of a Coriolis mass-flow meter［J］. European Journal of Control, 1998, 4: 196-207.
［11］Mayela Z, Msnus P H. An FPGA Implementation of a Digital CoriolisMass Flow Metering Drive System［J］. IEEE transactions on Industrial Electronics, 2008, 55(7): 2820-2831.
［12］Henry M P, Zamora M E. Startup techniques for a digital flowmeter［P］. US 2011/0185820A1.
［13］Manus H, Michael T, Mayela Z, et al. Coriolis mass flow metering for three-phase: A case study［J］. Flow Measurement and Instrumentation, 2013, 30: 112-122.
［14］张建国, 徐科军, 董帅, 等. 基于希尔伯特变换的科氏质量流量计信号处理方法研究与实现［J］. 计量学报, 2017, 38(3): 309-314.
Zhang J G, Xu K J, Dong S, et al. Study and Implementation of Signal Processing Method for Coriolis Mass Flowmeter Based on Hilbert Transform［J］. Acta Metrologica Sinica, 2017, 38(3): 309-314.
［15］侯其立, 徐科军, 李叶, 等. 用于微弯型科氏质量流量计的数字变送器研制［J］. 电子测量与仪器学报, 2011, 25(6): 540-545.
Hou Q L, Xu K J, Li Y, et al. Development of digital transmitter for micro-bend type Coriolis mass flowmeter［J］. Journal of Electronic Measurement & Instrument, 2011, 25(6): 540-545.
［16］纪爱敏, 李川奇, 沈连官. 科里奥利质量流量计研究现状与发展趋势［J］. 仪表技术与传感器, 2001, 6(4): 1-3.
Ji A M, Li C Q, Shen L G. Research Status and Development Trends of Coriolis Mass Flowmeter ［J］. Instrument Technique & Sensor, 2001, 6(4): 1-3.