|
|
|
| Experiment Investigation on Calibration of Hot Wire Anemometer Based on Low Air Speed Reference Facility |
| CUI Li-shui1,2,LI Peng2,QIU Li-rong1,LI Jian-shuang2 |
1. Beijing Institute of Technology, Beijing 100081, China
2. National Institute of Metrology, Beijing 100029, China |
|
|
|
|
Abstract The low air speed reference facility is established at NIM of China, based on the device, the experiment on calibration of hot wire anemometer is investigated.The facility is described in detail and the calibration method for hot wire sensor is introduced. Based on the reciprocity principle, the sensor probe is mounted on the carriage that slides with consistent speed and the sliding stroke is measured by laser interferometer accurately during calibration process. The velocity measurement is therefore traceable to the measurement of length and time primary standards, additionally, the parameters of static equation is obtained according to theoretical module of hot wire sensor, the experimental results are consistent with theoretical equation. The experimental results and uncertainty analysis show that the expanded uncertainty of the breeze standard device is U=0.82%（k=2）, and the expanded uncertainty of calibration result of hot wire anemometer is U=2.42%（k=2）.
|
|
Received: 18 October 2016
Published: 12 April 2018
|
|
|
|
|
|
［1］韦青燕,张天宏. 高超声速热线/热膜风速仪研究综述及分析［J］. 测试技术学报, 2012, 26（2）:142-149.
［2］论立勇,陈厚磊,蔡京辉.高压交变流动下热线风速仪标定方法研究［J］.实验流体力学,2010,24(3）:87-91.
［3］唐经文.热工测试技术［M］.重庆:重庆大学出版社,2008:190-195.
［4］崔骊水.基于激光多普勒测速仪的皮托管校准实验研究［J］.计量学报,2014,35(6):603-606.
［5］肖亚克,贾元胜,张孝棣,等.PIV 技术中的示踪粒子发生和布撒［J］.气动研究与实验,2005,22(4):8-15.
［6］李志平.激光粒子图像测量中示踪粒子特性及实验方法研究［D］.天津:天津大学,2007.
［7］黄志煌,刘俊杰,国凯. 激光粒子计数器校准中气溶胶稀释方法的研究［J］. 计量学报, 2016,37(4): 448-451.
［8］盛森芝,沈熊,舒玮.流速测量技术［M］.北京:北京大学出版社,1987:165-171.
［9］Spazzini P G, PiccatoA, Malvano R. Metrological features of the linear low-speed anemometer calibration facility at INRIM［J］. Metrologia,2010,46 (1):109-118.
［10］Terao Y , Choi Y M , Gutkin M , et al. Final report on the APMP air speed key comparison (APMP.M.FF-K3)［J］. Metrologia, 2010, 47(7): 88-94.
［11］冯建,李瑞君,何亚雄,等.微纳米三坐标测量机的高精度恒温箱研制［J］.计量学报,2015,36(5):455-459.
［12］张旭东,刘香斌,王世婕,等.新型移相量块干涉仪的研制［J］.计量学报, 2017,38(3):257-261. |
|
|
|
2018, Vol. 39 
