低氧分压下PtO2的分解机理研究

朱天梦; 潘家荣; 孙建平; 李婷; 李旭; 王成科

doi:10.3969/j.issn.1000-1158.2022.02.07

PDF(3800 KB)

计量学报 ›› 2022, Vol. 43 ›› Issue (2) : 184-190. DOI: 10.3969/j.issn.1000-1158.2022.02.07

热学计量

低氧分压下PtO₂的分解机理研究

朱天梦¹,潘家荣¹,孙建平²,李婷²,李旭²,王成科¹

作者信息 +

Research on the Decomposition Mechanism of PtO₂ in Low-oxygen Atmosphere

ZHU Tian-meng¹,PAN Jia-rong¹,SUN Jian-ping²,LI Ting²,LI Xu²,WANG Cheng-ke¹

Author information +

文章历史 +

摘要

高纯铂丝作为标准铂电阻温度计的传感元件,其氧化与分解机理是影响温度计稳定性的关键因素。采用差示量热扫描法与X射线光电子能谱共同分析了2种类型的铂氧化物PtO2和PtO在低氧分压下的分解过程。结果表明:2种氧化物的分解温度对氧气分压有明显的依赖性,氧气分压10kPa下,570℃时PtO2基本完全分解为Pt单质和PtO;在氧分压为3kPa下PtO;2的起始分解温度约为520℃,565℃以上大量分解为Pt单质,且当温度达到585℃时,PtO2分解为Pt的速度达到最快。研究结果可为铂电阻温度计的制作工艺、计量检定规程的完善提供数据参考和理论支持。

Abstract

High-purity platinum wires are used as the sensing elements of standard platinum resistance thermometers, the oxidation and decomposition mechanism affects the stability of the thermometers. Differential calorimetry scanning and X-ray photoelectron spectroscopy are used to analyze the decomposition process of two types of platinum oxides PtO2 and PtO in low oxygen atmosphere. The results show that the decomposition temperature of the two oxides is obviously dependent on the partial pressure of oxygen. At the partial pressure of 10kPa, PtO2 is basically completely decomposed into Pt and PtO at 570℃. At the oxygen partial pressure of 3kPa, the initial decomposition temperature of PtO;2 is about 520℃, and a large amount of Pt is decomposed above 565℃. When the temperature reaches 585℃, the decomposition rate of PtO2 into Pt is the fastest. The research results can provide data reference and theoretical support for the improvement of platinum resistance thermometers manufacturing process and metrological verification procedures.

导出引用

朱天梦,潘家荣,孙建平,李婷,李旭,王成科. 低氧分压下PtO₂的分解机理研究[J]. 计量学报. 2022, 43(2): 184-190 https://doi.org/10.3969/j.issn.1000-1158.2022.02.07

ZHU Tian-meng,PAN Jia-rong,SUN Jian-ping,LI Ting,LI Xu,WANG Cheng-ke. Research on the Decomposition Mechanism of PtO₂ in Low-oxygen Atmosphere[J]. Acta Metrologica Sinica. 2022, 43(2): 184-190 https://doi.org/10.3969/j.issn.1000-1158.2022.02.07

中图分类号： TB942

参考文献

［1］邓小龙, 孙建平, 乐恺, 等. 退火对标准铂电阻温度计性能影响的研究［J］. 计量学报, 2015, 36(1): 26-30.
Deng X L, Sun J P, Yue K, et al. The Annealing Effect on the Performance of the Standard Platinum Resistance Thermometer［J］. Acta Metrologica Sinica, 2015, 36(1): 26-30.
［2］牛亚路, 宋凯, 孙建平, 等. 空气环境下PtO;2分解实验的研究［J］. 计量学报, 2018, 39(1): 33-38.
Niu Y L, Song K, Sun J P, et al. Research on the Decomposition Experiment of PtO;2 in Air Environment［J］. Acta Metrologica Sinica, 2018, 39(1): 33-38.
［3］高凯, 蒋庆, 孙建平, 等. 铂丝位错特性对标准铂电阻温度计稳定性影响的研究［J］. 计量学报, 2020, 41(11): 1352-1357.
Gao K, Jiang Q, Sun J P, et al. Influence of Platinum Dislocation Characteristics on the Stability of Standard Platinum Resistance Thermometer［J］. Acta Metrologica Sinica, 2020, 41(11): 1352-1357.
［4］Berry R J . Study of multilayer surface oxidation of platinum by electrical resistance technique［J］. Surface Science, 1978, 76(2): 415-442.
［5］Berry R J. Effect of Pt Oxidation on Pt Resistance Thermometry［J］. Metrologica, 1980, 16(3): 117-126.
［6］Berry R J. Evaluation and control of platinum oxidation errors in standard platinum resistance thermometers［J］. Temperature, 1982, 5(3): 743-762.
［7］Berry R J. Platinum resistance thermometry in the range 630-900℃［J］. Metrologia, 1966, 2(2): 80-90.
［8］Sakurai H, Yamaguchi T, Hiura N, et al. Oxidization Characteristics of Some Standard Platinum Resistance Thermometers［J］. Japanese journal of applied physics, 2008, 47(10): 8071-8076.
［9］Sakurai H, Tamura O. Oxidization Characteristics of Standard Platinum Resistance Thermometers［J］. Japanese journal of applied physics, 2011, 50(1): 437-443.
［10］Jursic I, Rudtsch S. Thermal Stability of PtO Investigated by Simultaneous Thermal Analysis and Its Influence on Platinum Resistance Thermometry［J］. International Journal of Thermophysics, 2014, 35(6-7): 1055-1066.
［11］Ancsin J. Oxidation of platinum resistance thermometers［J］. AIP Conference Proceedings, 2003, 684(1): 345-350.
［12］蒋守红, 石文艳. 差示扫描量热仪(DSC)使用中应注意的一些问题［J］. 企业技术开发, 2013, 32(22): 33-35.
Jiang S H, Shi W Y. Some problems needing attention in application of Differential Scanning Calorimeter［J］. Technological Development of Enterprise, 2013, 32(22): 33-35.
［13］陈兰花, 盛道鹏. X射线光电子能谱分析(XPS)表征技术研究及其应用［J］. 教育现代化, 2018, 5(1): 180-182.
Chen L H, Sheng D P. Research and Application of X-ray Photoelectron Spectroscopy (XPS) Characterization Technology［J］. Education Modernization, 2018, 5(1): 180-182.
［14］Eberhardt W, Fayet P, Cox D M, et al. Photoemission from mass-selected monodispersed Pt clusters［J］. Physical review letters, 1990, 64(7): 780-783.
［15］Moulder J F, Stickle W F, Sobol P E, et al. Handbook of X-ray Photoelectron Spectroscop［M］. Eden Prairie : TPerkin-Elmer Corporation Physical Electronics Division, 1992.
［16］JJG 160—2007 标准铂电阻温度［S］.
［17］于帆,孙建平,李婷,等. 新制标准铂电阻温度计退火特性理论模型及验证［J］. 计量学报, 2021, 42(6): 759-764.
Yu F, Sun J P, Li T, et al. Theoretical Model and Verification of Annealing Characteristic of the New Standard Platinum Resistance Thermometer［J］. Acta Metrologica Sinica, 2021, 42(6): 759-764.
［18］任建平,孙建平,李婷,等. 标准铂电阻温度计自热效应对测量结果的影响［J］.计量学报, 2021, 42(5): 589-594.
Ren J P,Sun J P,Li T, et al. Influence of Self-heating Effect of Standard Platinum ResistanceThermometer on Measurement Results［J］. Acta Metrologica Sinica, 2021, 42(5): 589-594.