2025年04月07日 星期一 首页   |    期刊介绍   |    编 委 会   |    投稿指南   |    期刊订阅   |    统合信息   |    联系我们
计量学报  2019, Vol. 40 Issue (4): 681-685    DOI: 10.3969/j.issn.1000-1158.2019.04.22
  力学计量 本期目录 | 过刊浏览 | 高级检索 |
基于周期势函数的自适应二阶欠阻尼随机共振信号增强方法
陈剑1,2,陶善勇1,2,王维1,2,吕伍佯1,2
1.合肥工业大学 噪声振动工程研究所, 安徽 合肥 230009
2.安徽省汽车NVH工程技术研究中心, 安徽 合肥 230009
Adaptive Second-order Underdamped Stochastic Resonance Signal Enhancement Method Based on Periodic Potential Function
CHEN Jian1,2,TAO Shan-yong1,2,WANG Wei1,2,LÜ Wu-yang1,2
1. Institute of Noise and Vibration Engineering, Hefei University of Technology, Hefei, Anhui 230009, China
2. Automobile NVH Engineering & Technology Research Center Anhui Province, Hefei, Anhui 230009, China
全文: PDF (1385 KB)   HTML (1 KB) 
输出: BibTeX | EndNote (RIS)      
摘要 针对滚动轴承微弱故障振动信号在噪声环境下故障特征难以提取的问题,提出一种基于周期势函数的自适应二阶欠阻尼随机共振信号增强方法。采用粒子群算法对系统参数和阻尼系数的自适应匹配,实现对多个拟增强频段的随机共振,更加适用于工程实际中多故障信号提取。数据库考题检验和工程实验验证表明:1)该方法明显提高了输出信噪比,故障特征频率处主峰突出,边带干扰少,方便故障的机器判读,误判率低;2)随着噪声强度的增加,虽然输出信噪比有所降低,但该方法的检测效果仍优于基于周期势函数的自适应一阶随机共振方法的检测效果;3)该方法对噪声的适应性更强,在噪声环境下对于微弱故障信号的提取有着明显优势。
服务
把本文推荐给朋友
加入我的书架
加入引用管理器
E-mail Alert
RSS
作者相关文章
陈剑
陶善勇
王维
吕伍佯
关键词 计量学故障诊断滚动轴承周期势函数欠阻尼信噪比    
Abstract:Aiming at the problem that the faulty vibration signal of rolling bearing is difficult to extract under noisy environment, an adaptive second-order underdamped stochastic resonance signal enhancement method based on periodic potential function is proposed. The method uses particle swarm optimization to measure system parameters and damping. The adaptive matching of the coefficients realizes the stochastic resonance of multiple pseudo-enhanced frequency bands, and is more suitable for multi-fault signal extraction in engineering practice. The test of fault signal and the engineering experiment show that: 1) The adaptive second-order under-damped stochastic resonance method based on periodic potential function significantly improves the output signal-to-noise ratio, the main peak of the fault characteristic frequency is prominent. The sideband interference is less, the machine is easy to fault, and the false positive rate is low. 2) With the increase of noise intensity, although the output signal-to-noise ratio is reduced, the adaptive second-order underdamped stochastic resonance method based on periodic potential function, the detection effect is still better than the adaptive first-order stochastic resonance method based on periodic potential function. 3) The adaptive second-order under-damped stochastic resonance method based on periodic potential function is more adaptable to noise, in noisy environment, there are obvious advantages for the extraction of weak fault signals.
Key wordsmetrology    fault diagnosis    rolling bearing    periodic potential function    underdamping    SNR
收稿日期: 2018-07-16      发布日期: 2019-06-10
PACS:  TB936  
  TB973  
基金资助:安徽省科技重大专项(17030901049)
通讯作者: 陶善勇     E-mail: 754999472@qq.com
作者简介: 陈剑(1962-), 合肥工业大学教授,博士生导师。主要研究方向:机械系统低噪声设计与设备故障诊断。Email:Chenjian@hfut.edu.cn
引用本文:   
陈剑,陶善勇,王维,吕伍佯. 基于周期势函数的自适应二阶欠阻尼随机共振信号增强方法[J]. 计量学报, 2019, 40(4): 681-685.
CHEN Jian,TAO Shan-yong,WANG Wei,Lü Wu-yang. Adaptive Second-order Underdamped Stochastic Resonance Signal Enhancement Method Based on Periodic Potential Function. Acta Metrologica Sinica, 2019, 40(4): 681-685.
链接本文:  
http://jlxb.china-csm.org:81/Jwk_jlxb/CN/10.3969/j.issn.1000-1158.2019.04.22     或     http://jlxb.china-csm.org:81/Jwk_jlxb/CN/Y2019/V40/I4/681
京ICP备:14006989号-1
版权所有 © 《计量学报》编辑部
地址:北三环东路18号(北京1413信箱)  邮编:100029 电话:(010)64271480
本系统由北京玛格泰克科技发展有限公司设计开发  技术支持:support@magtech.com.cn